Sprache auswählen

Fuel smell in the garage

  • Racediagnostics
  • Autor
  • Offline
  • Elite
  • Elite
  • UK spec
Mehr
29 Mai 2021 22:03 - 29 Mai 2021 22:05 #276385 von Racediagnostics
Fuel smell in the garage wurde erstellt von Racediagnostics
The last couple of days there was a petrol smell in the garage, after a bit of searching I found there was a weep on the fuel return line at the tank where there is a short section of rubber hose.

It would normally be easy enough to find my fuel hose, I keep it in this box. 

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.



However we are moving house and I have started to pack up the contents of the garage. Luckily I only had to open ten boxes before finding it.

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.



Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.



I hope there's not 50l of petrol swilling round in the garage tomorrow morning, already tried pinching up the hose clips with no joy.

Cheers
Jim

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.


1979 450SL - 2002 XK8 4.2
Letzte Änderung: 29 Mai 2021 22:05 von Racediagnostics.

Bitte Anmelden oder Registrieren um der Konversation beizutreten.

  • Racediagnostics
  • Autor
  • Offline
  • Elite
  • Elite
  • UK spec
Mehr
30 Mai 2021 21:01 - 30 Mai 2021 21:03 #276438 von Racediagnostics
Racediagnostics antwortete auf Fuel smell in the garage
Car up on the ramp.

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.



This is the problem, surprising as its only 6 years old.

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.



I drained out ~50l into two 25l containers.

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.



Cut a new piece of hose and fitted it.

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.



An easy repair that was extended by the hour it took to drain the tank.

Cheers
Jim

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.


1979 450SL - 2002 XK8 4.2
Letzte Änderung: 30 Mai 2021 21:03 von Racediagnostics.

Bitte Anmelden oder Registrieren um der Konversation beizutreten.

Mehr
30 Mai 2021 21:33 #276443 von Chromix
Chromix antwortete auf Fuel smell in the garage
Hi Jim,

I once wondered about fuel smell from a car and found a similar situation:  a fuel line, that I had replaced only a few years ago, started to disintegrate.
I blamed the quality of the fuel line - I had bought it as a no-name product from a local car parts dealer. Now I bought Continental and Cohline fuel lines and hope that they will serve me better.

Cheers,
Lutz

Alle Lebewesen außer den Menschen wissen, daß der Hauptzweck des Lebens darin besteht, es zu genießen.
Samuel Butler

Bitte Anmelden oder Registrieren um der Konversation beizutreten.

  • Racediagnostics
  • Autor
  • Offline
  • Elite
  • Elite
  • UK spec
Mehr
30 Mai 2021 21:52 #276445 von Racediagnostics
Racediagnostics antwortete auf Fuel smell in the garage
Hi Lutz,

The surprising thing was that this is Cohline 2122.

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.



Perhaps the hose clip was too tight.

Cheers
Jim

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.


1979 450SL - 2002 XK8 4.2

Bitte Anmelden oder Registrieren um der Konversation beizutreten.

Mehr
30 Mai 2021 23:00 #276452 von Dr-DJet
Dr-DJet antwortete auf Fuel smell in the garage
Hi Jim,

I do not use fuel hose with loose textile wrapping any more. It gets soft and then you have leakage or blockage. Such a 5 years old hose has once made me look like a fool on the occasion of my very 1st D-Jetronic workshop on vdh Pfingsten meeting. Just after I arrived it blocked reflow to tank and my 450 SL ran like a Diesel. People were joking with me that I should see a D-Jetronic specialist.

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.



I only use fuel hoses with 2 rubber mixtures NBR inside and another outside plus enforcing tissue in between like this one . It costs much more but I have better experience. Blockage happened at a  place where I should have used a 90° molded hose. But leakage happend at other places.

Viele Schraubergrüße - best regards, Volker, Admin und Betreiber dieser Webseite
Fast alles zu Zündung und Jetronic auf jetronic.org

Workshop Hzg/Klima 13.4 (ER), D-Jetronic 8.6. (F) & 20.7. (ER), K-Jetronic 29.6. (ER) & 31.8. (F)

Dieses Bild ist für Gäste verborgen.
Bitte anmelden oder registrieren um das Bild zu sehen.


Folgende Benutzer bedankten sich: Racediagnostics, Yngve, KaiDase

Bitte Anmelden oder Registrieren um der Konversation beizutreten.

Mehr
03 Juni 2021 08:36 #276662 von MB350SLC
MB350SLC antwortete auf Fuel smell in the garage
Hi Jim, Volker,

had exactly the same experience with the fabric wrapped fuel hose. I purchased mine directly from MB and after max 3 years the rubber was worn along the weave lines of the fabric. Interesting other people had the same problem.

Cheers,

Phil
Folgende Benutzer bedankten sich: Racediagnostics

Bitte Anmelden oder Registrieren um der Konversation beizutreten.

Mehr
04 Juni 2021 08:40 #276717 von messerfloh
messerfloh antwortete auf Fuel smell in the garage
I can second that. Those braided  hoses are from the 1950´s and I always wonder why they are still sold nowadays. Maybe in the good ole times the rubber was better or the gas was not as agressive as today, but still this type of hose is just for the bin. Take a hose like Volker suggests and you´ll avoid those problems in future.

Scheene Griaß
da Floh


450SLC ´75 Silbergrün

Bitte Anmelden oder Registrieren um der Konversation beizutreten.

Moderatoren: RagettiObelix116
Ladezeit der Seite: 0.114 Sekunden
Powered by Kunena Forum
Cookies erleichtern die Bereitstellung unserer Dienste. Mit der Nutzung unserer Dienste erklären Sie sich damit der Datenschutzerklärung und der Verwendung von Cookies einverstanden.